Furnace Condensate Drain Pipe

Codes installation leaks clogs connections troubleshooting repair.

Furnace condensate drain pipe. Condensate switches imc 307 2 3 states that all hvac equipment that produces condensate must have either a secondary drain line or a condensate overflow switch a secondary drain pan with a secondary drain line or condensate switch or some combination of these installations should be used to prevent overflow if the primary drain line blocks. You can prevent slime and eliminate drain tube clogs in two easy steps. This is what a service tech did to the vent. Most drain lines will have a t shaped vent tee with a cover or cap.

So far i only get the run around and no answer. First remove the drain tube and fitting. To hide the drain pipe run the condensation drain into a buried drainage line which can then be routed downhill and away from the yard. Can a condensate line coming off of the furnace to the floor drain have it s vent pipe covered with duct tape on the top.

The easiest solution is to attach an extension pipe or hose to your ac drain then extend it downhill away from the house or into a thirsty flower bed. I removed the duct tape. Enter the condensate line which essentially functions as a drain line. This article discusses the inspection and repair or un clogging of condensate disposal systems including air conditioning heat pump or condensing boiler furnace condensate drains condensate pumps and their proper installation as part of our review of condensate piping traps drains.

I have been trying to get an answer from the furnace company as to why this was done. Condensate lines are typically made of plastic commonly pvc or sometimes metal although plastic is prefered. When you see water puddling around the furnace with the a c running you have a clogged condensate drain tube. All condensate drains go into a trap.

Its job is to efficiently funnel condensation away from your hvac unit. A c condensate drains pumps. Identify the access point on the drain line. Additionally the inducer motor would suck air through the.

The condensate trap is absolutely mandatory for a high efficiency gas furnace. Since the drain taps into the exhaust system leaving it open to the air would allow for a potential exhaust flue gas leak in the living space which is a big no no. Your drain line is a pvc pipe located near your outdoor unit and is attached to the wall of your house. It connects directly to the hvac unit and leads outdoors often through an exterior wall.